you are here >> home > sanitary products
> aseptol 2000
PSAN-ASEP105
For swine producers. A basic method for
a guaranteed hygiene.
Scours problems ? Use Aseptol 2000.
Virucidal, bactericidal and fungicidal disinfectant.
Very powerful, non-toxic and
non-corrosive disinfectant for hard and non-porous surfaces for
agricultural use in lodging, materials and animal transportation
vehicles.
Characteristics
Characteristics
ASEPTOL 2000 combines at the same time a detergent and disinfectant
action. The detergent capacity is obtained by the presence of 3 high
concentration quaternary ammonium. The quaternary ammonium is as tensioactive as soap
because of the presence of an hydrophilic pole (attracted by water
molecules) and by an hydrophobic pole (attracted by lipids). Therefore, it has a foaming and detergent ability
recognized to be able to attack and disorganize residual organic film
that exists on hard and porous surfaces.
.
So,
they are soaking, emulsifying and soluble agents. They also have a
disinfectant power especially on bacteria and wrapped viruses. The glutaraldehyde is a disinfectant from the
aldehydes family, approximately 20 times more powerful than
formaldehyde. It is active at the same time on viruses (nude viruses
included), bacteria and fungus. It's high concentration in the
ASEPTOL 2000 formula allows a disinfectant action even when used on
low dosage.
Technidal data
Format
Sanction number DIN 02266814 law on PCP products
Exclusively distributed in North America by S.E.C.
Repro inc.
Containers of 5
litres, 20 litres, 60 litres and 200 litres
Directions for use
:
By spraying
With a dose of 0,5 % to 1 % (1 to 2
litres of ASEPTOL 2000 for 200 liters of water) : spray 200 to
400 liters of solution for 1000m2 of surface to treat.
By
soaking
Foot bath : 1,5
%; renew every 2 to 3 days. Material : 0,5 % to 1 %.
By dynafog (fine
particules)
1,6 ml of pure ASEPTOL 2000 for 1m3
without the presence of animals. Keep room closed for 2
hours.
Quantity of
disinfectant to use for :*
Farrowing
34ml/ sow unit
Nursery
2,5ml/ piglet
unit
Grower/ finisher
6ml/ swine unit (on slats)
Foot
bath
15ml/ litre
(dilution of 1.5 %) every 2 to 3 days
Material
10ml/ litre (dilution of 1 %)
Transport
vehicles
1.5 ml/ m2 of
surface to treat
Fumigation/
thermonebulisation
1.6 ml/ m3 when the animals are out.
Close room for 2 hours.
*NB : it takes
300ml of Aseptol 2000 per square meter of surface to treat
(1,5ml pure/m2), these quantites were calculated with the help
of a foamer and/or pressure washer. These quantities amount to
a 0.5 % utilisation.
ASEPTOL 2000 combines at the same time a detergent and disinfectant
action. The detergent capacity is obtained by the presence of 3 high
concentration quaternary ammonium.
